For the back bracket bolt stand over the pump and look down behind the pump and you will see the last bracket bolt. The other 3 hold the bracket to the car, 2 in front, and one in back. There are 6 bolts in all, 3 bolts holding the pump to the bracket, 2 in front, and the one in back of the pump. All bolts are the same size as the pulley 6mm allen key head socket that hold the pump and bracket in.
The bolt in the back of the pump is impossible to reach.
You cannot remove the pump wthout removing the bracket with it. Once belt and pulley are removed you can now start unbolting the pump bracket. You will see a piece if you look to the right of your tensioner pulley,that is where the wrench goes.ģ. You may have to turn over the engine for a second to get the last bolt to land in a place where u can loosen it, once again space is restricted.Ģ.Once u have removed the bolts for the pulley take your 19 mm wrench and press on the tensioner to release the tension on the drive belt. Now loosen the three bolts connecting the p/s pump to its pulley with your homemade tool. Then connect your six inch 3/8 extension so u should have a 3/8 extension with a flexible head with your 6mm allen head socket attached to the flexible head. Not to the ratchet for space is restricted. Pull the rubber stripping off for a lil more space as shown in pic.Take your 6mm allen head(hex head) socket and attatch it to your 3/8 flexible attachment. start by removing the cover over the power steering pump. and didnt pay a penny for my replacements other than shipping on one i ordered off the net now i have an xtra pump lol.ġ. If u have already replaced ur pump dont forget to check to see if u have a manufacturers warranty i sent back both pumps i had replaced at a shop. I highly recommend doing a power steering flush post installation and replacing all clamps and any bad hoses upon pump transfer
#AUDI A6 2006 STEERING WHEEL PUMP AFTERMARKET FULL SIZE#
B6 3.0 Quattro 2002 *view full size photos in audizine photo gallery* a4ridinĪ replacement pump go with new or remanufactured, which ever has the best warrantyĢ2mm socket that can attach to a 3/8 driveĢ liters of vw audi power steering fluid or pentosin chf 11s (2 liters should be enough for topping off reservoir post installation and do a lil bit of flushing of the system)Ī jack that can get both front wheels off the groundĪ friend on hand to assist for some of the diy u can do most by yourself